k铁路工程试验表格.doc

《k铁路工程试验表格.doc》由会员分享，可在线阅读，更多相关《k铁路工程试验表格.doc（60页珍藏版）》请在三一办公上搜索。

1、 中华人民共和国行业标准 铁建设函200927号铁 路 工 程 试 验 表 格 20090108 发布 20090108 实施中华人民共和国铁道部 发布中华人民共和国行业标准铁 路 工 程 试 验 表 格主编单位：铁道部经济规划研究院批准部门：中华人民共和国铁道部施行日期：2009年1月8日2009年北京前 言本试验表格是根据铁道部关于印发2004年铁路工程建设规范定额标准设计编制计划的通知（铁建设函200442号）的要求，在铁路工程试验表格（铁建函（97）203号）基础上修订而成的。本试验表格是为适应铁路工程试验检测工作需要，进一步提高标准化管理水平，按照系统、规范、科学、实用的原则进行编制

2、的。编制过程中进行了深入的调查研究，全面总结了铁路工程试验工作的实践经验，认真分析了相关技术标准的变化与要求，及时吸纳了新技术应用成果，体现了信息全面、格式规范、步骤合理、简明实用的特点。本次修订的主要内容如下：1适应盲样检测需要，“委托单位”、“工程名称”、“施工部位”等信息不在试验记录表中体现，移至试验任务委托单中表达。2根据高性能混凝土的技术要求，全面整合原材料品质、配合比选定、过程质量控制等方面的试验检测项目。3满足工程实体质量检查需要，增加混凝土结构无损检测类表格。4体现路基压实质量多指标控制特点，增加K30、EVd、EV2等试验表格。5根据碎石道砟技术标准的变化，修改相关试验表格。

3、6为控制防水材料质量和保证防水效果，完善防水试验表格及检验项目。7增加速凝剂、锚固剂性能和锚杆锚固质量等试验表格。8在无砟轨道技术控制方面，增加水泥乳化沥青砂浆等试验表格。9删除非铁路工程用的装饰材料方面的有关表格。如釉面内墙砖、彩色釉面陶瓷墙地砖、大理石板材等。10 增加试验和管理方面的通用表格，以适应技术发展需要，便于现场灵活掌握。本试验表格主要内容包括：水泥、粗细骨料、掺和料、外加剂、拌和用水、混凝土（砂浆）配合比、混凝土力学性能和耐久性能、混凝土无损检测、混凝土构件性能、水泥乳化沥青砂浆试验、岩石和土工试验、原位测试、填土密度、钢材、道砟、锚杆、防水材料、石灰等的试验记录和试验报告。在

4、执行本试验表格过程中，希望各单位结合工程实践，认真总结经验，积累资料。如发现需要修改和补充之处，请及时将意见及有关资料寄交铁道部经济规划研究院（北京市海淀区羊坊店路甲8号，邮政编码：100038），供今后修订时参考。本试验表格由铁道部建设管理司负责解释。本试验表格主编单位：铁道部经济规划研究院。本试验表格参编单位：中铁一局集团有限公司、中铁二局集团有限公司、中铁三局集团有限公司、中铁四局集团有限公司、中铁六局集团有限公司、中铁十二局集团有限公司、中铁十四局集团有限公司、中铁十五局集团有限公司、中铁十六局集团有限公司、中铁十七局集团有限公司、中铁十八局集团有限公司、中铁十九局集团有限公司、中铁二

5、十四局集团有限公司、中铁二十五局集团有限公司、中铁隧道局集团有限公司、中铁第四勘察设计院、中铁第五勘察设计院、中国铁道科学研究院。 目 次第一部分 试验记录水泥试验记录1细骨料试验记录4粗骨料试验记录8混凝土用骨料碱活性试验记录11轻骨料试验记录14用于水泥和混凝土中的粉煤灰试验记录17用于水泥和混凝土中的粒化高炉矿渣粉试验记录19混凝土外加剂性能试验记录21混凝土外加剂匀质性试验记录25液体速凝剂匀质性试验记录28粉体速凝剂匀质性试验记录29速凝剂性能试验记录30水质简易分析记录31混凝土配合比选定记录33混凝土施工配料通知单37混凝土拌和物凝结时间测定记录38混凝土试件抗压强度试验记录40

6、混凝土抗折强度试验记录41混凝土劈裂抗拉强度试验记录42混凝土静力受压弹性模量试验记录43铁路混凝土强度检验评定记录44混凝土抗冻性能试验记录47混凝土抗渗性能试验记录49混凝土电通量快速测定记录50混凝土抗裂性试验记录51混凝土收缩试验记录52钻芯法检测现场操作记录54钻芯法芯样抗压强度试验记录55混凝土结构实体钢筋保护层厚度检测记录56回弹法评定混凝土强度检测记录57超声回弹法评定混凝土强度检测记录58后装拔出法评定混凝土强度检测记录59同条件养护法养护温度记录60预应力混凝土铁路桥简支梁静载弯曲试验记录61梁体管道压浆剂（料）试验记录62梁体管道压浆检查试件强度试验记录63锚具锚固拉力极

7、限总应变试验记录64砂浆配合比选定记录65砂浆施工配料通知单68砂浆检查试件抗压强度试验记录69支座自流平砂浆试验记录70水泥乳化沥青砂浆试验记录72水泥乳化沥青砂浆施工配料通知单80硫磺砂浆配合比试验记录81硫磺锚固检测记录82锚杆抗拔试验记录83锚杆锚固剂试验记录85吸水式锚固包试验记录86金属材料机械性能试验记录88金属材料焊接接头机械性能试验记录89金属洛氏硬度试验记录90金相试验记录91钢材化学分析试验记录92钢筋试验记录94钢筋焊接接头试验记录95钢筋机械连接接头试验记录96预应力混凝土用钢绞线试验记录97预应力混凝土用钢丝试验记录98碎石道砟试验记录99岩石试验记录104岩石薄片

8、鉴定记录114点荷载试验记录115土的含水率试验记录117土的密度试验记录120土的颗粒密度试验记录121黏性土液塑限联合试验记录122黏性土碟式仪液限、搓条法塑限试验记录123黏性土收缩皿法缩限定试验记录124筛析法颗粒分析试验记录125密度计法颗粒分析试验记录126移液管法颗粒分析试验记录127标准固结试验记录12812h快速固结和1h快速压缩试验记录130三轴压缩试验记录131湿化试验记录134黄土湿陷性试验记录135收缩试验记录136直接剪切试验记录137常水头渗透试验记录139变水头渗透试验记录140无侧限抗压强度试验记录141击实试验记录142膨胀力试验记录143膨胀率试验记录14

9、4自由膨胀率试验记录145砂的相对密度试验记录146碎石类土相对密度试验记录147改良土无侧限抗压强度试验记录148基床表层级配碎石试验记录149基床表层级配砂砾石试验记录151过渡段级配碎石试验记录153承载比试验记录154易溶盐试验综合记录156比浊法SO42-试验记录157原子吸收光度法钠离子钾离子测定记录158中溶盐试验记录159难溶盐试验记录161有机质含量试验记录162阳离子交换量试验记录163蒙脱石含量试验记录164EDTA滴定法标准曲线试验记录165灰剂量试验记录166静力触探试验记录167动力触探试验记录168十字板剪切试验记录（电测式）169回弹模量试验记录170灌砂法测定

10、填料压实密度试验记录171灌水法测定填料压实密度试验记录172气囊法测定填料压实密度试验记录173环刀法测定填料压实密度试验记录174核子射线法测定填料压实密度试验记录175K30平板载荷试验记录176K30平板载荷仪校验记录177动态变形模量EVd试验记录178静态变形模量EV2试验记录179沥青及改性沥青试验记录180乳化沥青试验记录184沥青胶结材料试验记录186水泥乳化沥青砂浆用干料试验记录187防水材料试验记录189防水涂料试验记录193止水带试验记录194软式透水管试验记录198石灰试验记录200烧结普通砖试验记录201(通用)试验记录203第二部分 试验报告水泥试验报告204细骨

11、料试验报告205粗骨料试验报告206混凝土用骨料碱活性试验报告207轻骨料试验报告208用于水泥和混凝土中的粉煤灰试验报告209用于水泥和混凝土中的粒化高炉矿渣粉试验报告210混凝土外加剂性能试验报告211混凝土外加剂匀质性试验报告212液体速凝剂试验报告213粉体速凝剂试验报告214水质简易分析报告215混凝土配合比选定报告216混凝土试件抗压强度试验报告217混凝土抗折强度试验报告218混凝土劈裂抗拉强度试验报告219混凝土静力受压弹性模量试验报告220铁路混凝土强度检验评定报告221混凝土抗冻性能试验报告222混凝土抗渗性能试验报告223混凝土电通量快速测定报告224混凝土抗裂性试验报告

12、225混凝土收缩试验报告226钻芯法评定混凝土强度检测报告227混凝土结构实体钢筋保护层厚度检测报告228回弹法评定混凝土强度检测报告229超声回弹法评定混凝土强度检测报告230后装拔出法评定混凝土强度检测报告231预应力混凝土铁路桥简支梁静载弯曲试验报告232梁体管道压浆剂（料）试验报告233梁体管道压浆检查试件强度试验报告234锚具锚固拉力极限总应变试验报告235砂浆配合比选定报告236砂浆检查试件抗压强度试验报告237支座自流平砂浆试验报告238水泥乳化沥青砂浆试验报告239硫磺砂浆配合比试验报告241硫磺锚固检测报告242锚杆抗拔试验报告243锚杆锚固剂试验报告244吸水式锚固包试验报

13、告245金属材料机械性能试验报告246金属材料焊接接头机械性能试验报告247金属洛氏硬度试验报告248金相试验报告249钢材化学分析试验报告250钢筋试验报告251钢筋焊接接头试验报告252钢筋机械连接接头试验报告253预应力混凝土用钢绞线试验报告254预应力混凝土用钢丝试验报告255碎石道砟试验报告256岩石试验报告258岩石薄片鉴定报告260点荷载试验报告261土工试验报告262改良土无侧限抗压强度试验报告265基床表层级配碎石试验报告266基床表层级配砂砾石试验报告267过渡段级配碎石试验报告268承载比试验报告269土工化学分析综合报告270灰剂量试验报告271静力触探试验报告272动

14、力触探试验报告273十字板剪切试验报告（电测式）274回弹模量试验报告275填料压实质量试验报告276沥青试验报告277改性沥青试验报告278乳化沥青试验报告279沥青胶结材料试验报告280水泥乳化沥青砂浆干料试验报告281防水材料试验报告282防水涂料试验报告283止水带试验报告284软式透水管试验报告285石灰试验报告286烧结普通砖试验报告287(通用)试验报告288第三部分 试验通用管理表格工程试验人员动态年报289试验任务委托单290委托试验管理台帐291仪器设备运转记录292监视和测量装置台帐293监视和测量装置周期检定/校准计划29458（英文版 ） Two regulation

15、s promulgated for implementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiativ

16、es. The two regulations supporting each other, the adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; around the party discipline, disciplinary ruler requirements, listed as negative list, focusing on vertical gaug

17、e, draw the party organizations and Party members do not touch the bottom line . Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fu

18、ndamental principles of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. and revised the necess

19、ity and revised history of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines and column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom

20、of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the partys leadership, to solve the masses of the people reflect

21、 a focus on the problem. The new revision of the and , reflects the partys 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the partys eightee

22、n years comprehensive strictly practice. (a) revised two regulations of the party need of in based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play an important role. But with the party to manage the party strict

23、ly administering the deepening, has not been able to fully meet the actual needs. Content is too complicated, eight prohibition, 52 are not allowed to hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive,

24、 no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to clean the theme is not prominent, not for the existing problems, and is narrow, only needl

25、e of county-level leading cadres above. is in 1997 based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to fully meet the comp

26、rehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage the a

27、uthority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to and the two is likely to be more relevant regulations first amendment. By rev

28、ising, really put the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of Ch

29、ina attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations made clear instructions. According to the central deployment, the Central

30、Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifie

31、s the direction, major issues of principle, path and target, respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs Department The first party committee

32、is mainly responsible for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provin

33、ces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline

34、 Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft

35、. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, and revision of the basic principles of two party regulations revision work and implement the pa

36、rtys eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised and , highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based

37、 on the current, a long-term, advance as a whole, with Bu Xiuding independent and . Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, mai

38、ntaining the authority of the constitution. General Secretary Xi Jinping pointed out that no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plena

39、ry Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules. the revision of the and is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the

40、party constitution as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations gov

41、erning the party and the party. The Party of rule of virtue de, mainly refers to the partys ideals and beliefs, excellent traditional style. The revised the closely linked to the self-discipline, insisting on the positive initiative, for all members, highlight the vital few, emphasized self-discipli

42、ne, focusing on the morality, and the majority of Party members and the ideological and moral standards. The revised Ji method separately, Ji, Ji Yan to Method, as a negative list, emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict p

43、arty discipline and practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in the party at the present sta

44、ge, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the partys eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of t

45、he spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the and modified and needs to grasp several key problems (a) adhere to according t