LANDROVER工具使用说明.doc

《LANDROVER工具使用说明.doc》由会员分享，可在线阅读，更多相关《LANDROVER工具使用说明.doc（52页珍藏版）》请在三一办公上搜索。

1、Land Rover Mandatory Tooling序号编号英文名称中文名称图片适用车型1LRT-12-001Centraliser, Clutch离合器定位工具Discovery V8 Manual shift only2LRT-12-013Remover / Replacer Gudgeon Pin Basic Tool活塞销拆装工具Discovery V8 only3LRT-12-034pressor Valve Spring气门弹簧压缩工具Discovery V8 and Freelander KV6 and Rangerover V84LRT-12-037Drift Remove

2、r E*haust Valve Guide排气门导管拆卸冲头Discovery V8 only5LRT-12-039AValve Guide Drift气门导管冲头Discovery V8 only6LRT-12-052CEngine Oil Pressure Test Equipment发动机机油压力测试表All7LRT-12-061Protection Sleeve Crankshaft Rear Oil Seal曲轴后油封保护套管Freelander KV6 only8LRT-12-071Remover Oil Seal Valve Stem气门油封拆卸工具Freelander KV6

3、only9LRT-12-080Holding Tool, Pulley Crankshaft曲轴皮带轮固定工具Discovery V8 only10LRT-12-088Remover, Timing Cover Oil Seal正时盖油封拆卸工具Discovery V8 only11LRT-12-089Replacer , Timing Cover Oil Seal正时盖油封安装工具Discovery V8 only12LRT-12-091Replacer , Rear Oil Seal Crankshaft曲轴后油封安装工具Discovery V8 only13LRT-12-093Retai

4、ning Tool Viscous Coupling黏液耦合器定位工具Discovery V8 only14LRT-12-094Wrench, Viscous Coupling粘液耦合器扳手Discovery V8 only15LRT-12-095Protector, Rear Main Oil Seal后主油封保护器Discovery V8 only16LRT-12-126Remover / Replacer, Gudgeon Pin活塞销拆卸工具Discovery V8 only17LRT-12-129Remover Replacer, Oil Pump凸轮轴前油封拆卸螺杆工具Freela

5、nder KV6 only18LRT-12-138Engine Lift and Tilt Tool发动机吊装工具Freelander KV6 only19LRT-12-144Retainer Clamps, Cylinder Liner半湿式缸套定位夹Freelander KV6 only20LRT-12-147Remover Camshaft Oil Seal凸轮轴油封拆卸工具Freelander KV6 only21LRT-12-148AReplacer Camshaft Oil Seal凸轮轴油封安装工具Freelander KV6 only22LRT-12-161Wrench, Lo

6、cking, Crank Pulley曲轴皮带轮锁止工具Freelander KV6 only23LRT-12-169Wrench, Engine Mount发动机固定胶拆装扳手Freelander KV6 only24LRT-12-175Fi*ture, Locking, Cam Pulleys凸轮轴皮带轮锁止对正时工具Freelander KV6 only25LRT-12-179Handle, Replacer, Crankshaft, Oil Seal油封后油封安装工具把手New Range Rover V8 only26LRT-12-183Aligning Blocks, Sump.油

7、底壳定位块Discovery V8 only27LRT-12-195Spreader, Timing Belt.正时皮带紧器Freelander KV6 only28LRT-12-196Locking Plates, Camshaft - 2.5 Ltr (2 off)凸轮轴锁止盘(2.5V6)Freelander KV6 only29LRT-12-197Wrench Adaptor, Camshaft Belt Timing.凸轮轴皮带轮Freelander KV6 only30LRT-12-198Locating Pins, Timing Belt.正时皮带锁止销Freelander KV

8、6 only31LRT-12-199Handle.辅助手柄Freelander KV6 only32LRT-12-200Remover, Crankshaft Front Oil Seal.曲轴前油封拆卸工具Freelander KV6 only33LRT-12-202Replacer, Crankshaft Front Oil Seal.曲轴前油封安装工具Freelander KV6 only34LRT-12-204Piston Ring Clamp.活塞环安装夹具Freelander KV6 Discovery V8 Range Rover V835LRT-12-208Distance P

9、iece, Valve Guide Rep气门油封安装工具Freelander KV6 only36LRT-12-214Wrench, Viscous Fan.粘液耦合器风扇扳手Discovery V8 and Range Rover V837LRT-12-215Wrench, Viscous Fan.粘液耦合器风扇拆装扳手New Range Rover V8 only38LRT-12-216Engine Lifting Bracket.发动机举升支架New Range Rover V8 only39LRT-12-217Installer, Crankshaft Rear Oil Seal.曲

10、轴后油封安装工具New Range Rover V8 only40LRT-12-218Protector, Crankshaft Rear Oil Seal.曲轴后油封保护套New Range Rover V8 only41LRT-12-219Locking Tool, Flywheel飞轮锁止工具New Range Rover V8 only42LRT-12-220Locking Tool, Camshaft Tensioner.凸轮轴紧器锁止工具New Range Rover V8 only43LRT-12-221Adjustment Tool, Camshaft Tensioner.凸轮

11、轴紧器调整工具New Range Rover V8 only44LRT-12-222Adjustment Bolt, Camshaft Tensioner.凸轮轴紧器调整工具New Range Rover V8 only45LRT-12-223Locking Fi*ture.凸轮轴固定架New Range Rover V8 only凸轮轴固定架New Range Rover V8 only46LRT-12-224Socket, VCC Unit Adjustment.VCC单元调整套筒New Range Rover V8 only47LRT-12-225Alignment Tools, Upp

12、er Timimg Cover.上凸轮轴盖定位工具New Range Rover V8 only48LRT-12-226Socket, VCC Solenoid Control Valve.VCC电磁阀拆卸套筒New Range Rover V8 only49LRT-12-227Timing Pin.正时定位销New Range Rover V8 only50LRT-12-228Timing Tools.正时固定工具New Range Rover V8 only51LRT-12-229Holding Tool, Crankshaft.曲轴定位工具New Range Rover V8 only5

13、2LRT-12-230Remover, Crankshaft Front Oil Seal.曲轴前油封拆卸工具New Range Rover V8 only53LRT-12-231Installer, Crankshaft Front Oil Seal.曲轴前油封安装工具New Range Rover V8 only54LRT-12-232Timing Pin, Flywheel飞轮正时锁止销Freelander KV6 only55LRT-12-501Basic Handle Set Valve Seat Cutter手动气门座铰刀Discovery V8 only56LRT-12-503E

14、*pandable Pilot气门铰刀定位棒Discovery V8 only57LRT-12-517Valve Seat Cutter手动气门座铰刀Discovery V8 only58LRT-12-519Valve Guide Remover/Replacer手动气门座铰刀Freelander KV659LRT-19-006AAdaptor, Fuel Rail Pressure Test燃油压力测试接头Freelander KV6& Rangerover V860LRT-19-009Fuel Tank Lockring Wrench油箱盖扳手All61LRT-19-013Adaptor

15、Fuel Pressure Test.燃油压力测试表Discovery V8 62LRT-19-014Wrench 02 Sensor.氧传感器扳手Freelander KV6 only63LRT-37-011Adaptor / Remover Layshaft Bearing传动轴中央轴承拆卸工具Freelander KV6 Rangerover64LRT-37-014Replacer Mainshaft Oil Seal变速器及分动器油封安装工具Freelander KV6 only65LRT-41-001Adaptor Centre Differential Bearing Remove

16、r中央差速器主轴轴承拆卸工具Discovery V8 only66LRT-41-002Adaptor Centre Differential Bearing Remover Front Bearing中央差速器主轴前轴承拆卸工具Discovery V8 only67LRT-41-003Remover / Replacer Input Gear Bearing Cone中央差速器主轴锥形轴承拆卸工具Discovery V8 only68LRT-41-004Dummy Shaft, Intermediate Gear齿轮中间轴Discovery V8 only69LRT-41-005Mandrel

17、 Input Gear Turning Tool输入齿轮套筒Discovery V8 only70LRT-41-006Adaptor Replacer Intermediate Gear Bearing中间齿轮轴承拆卸接头Discovery V8 only71LRT-41-007Remover / Replacer Adaptor Socket Differential Nut差速器螺母拆卸套筒Discovery V8 only72LRT-41-008Replacer Differential Bearing Centre差速器中央轴承安装工具Discovery V8 only73LRT-41

18、-009Guide Stud Alignment Transfer Bo* To Main Gearbo*分动器到主变速器定位销Discovery V8 only74LRT-41-011Replacer, Oil Seal Transfer Bo* -(Output & Input Shaft)分动箱输入输出轴油封安装工具Discovery V8 only75LRT-41-012Replacer, Oil Seal, Transfer Bo*分动箱油封安装工具Discovery V8 only76LRT-41-014Depth GaugeDiff Bearing差速器轴承深度表Discover

19、y V8 only77LRT-41-015Replacer Input Shaft Oil Seal (IRD Unit)IRD输入轴油封安装工具Freelander KV6 only78LRT-41-016High Ratio Cable Setting Pin上下档拉线设定销Discovery V8 only79LRT-41-017Setting Pillar Transfer Bo* Gear Cluster分动箱齿轮组设定座Discovery V8 only80LRT-41-018Remover/Replacer, Transfer Bo* Mounting Bush.分动器固定胶套拆

20、卸安装工具New Range Rover V8 onlyNew Range Rover V8 only81LRT-41-019Replacer, Transfer Bo* Input Shaft Seal.分动箱输入轴油封安装工具New Range Rover V8 only82LRT-41-020Replacer, Transfer Bo* Ouput Shaft Seal.分动箱输入轴油封安装工具New Range Rover V8 only83LRT-44-001Replacer, Oil Seal, Front & Rear前后轮毂油封安装工具Discovery V8 only84LR

21、T-44-003Gauge End Float端部跳动测量工具Discovery V8 only85LRT-44-005Remover / Replacer Control Unit Oil Seal阀体油封拆卸安装工具Discovery V8 only86LRT-44-010Lifting Handle, Convertor液力耦合器运输把手Discovery V8 and New Range Rover V887LRT-44-011Setting Tool Selector Position换档杆位置设定工具Discovery V8 only88LRT-44-012Replacer Out

22、put Shaft inner Seal输出轴油封安装工具Discovery V8 only89LRT-44-018Lever & Pin, Neutral Position档位开关空档设定工具Freelander KV6 only90LRT-44-024Replacer, Seal, Torque Converter液力耦合器油封安装工具Freelander KV6 only91LRT-44-027Replacer, Oil Seal.油封安装工具Freelander KV6 only92LRT-44-026Lifting Bracket.神行者支撑架Freelander KV6 only9

23、3LRT-44-029Replacer, Rear Housing Oil Seal.后桥壳油封安装工具New Range Rover V8 only94LRT-44-031Replacer, Torque Convertor Oil Seal.液力耦合器油封安装工具New Range Rover V8 only95LRT-44-032Support Bracket (ZF Gearbo*).ZF变速器支撑架New Range Rover V8 only96LRT-44-033Remover/Replacer Selector Shaft Oil Seal.换档轴油封安装拆卸工具New Ran

24、ge Rover V8 only97LRT-51-003Holding Wrench Adjustable Flange可调法兰固定扳手All98LRT-51-008Remover, DifferentialFlange Centralising Peg差速器法兰中央塞拆卸工具Discovery V8 only99LRT-51-009Replacer Pinion Oil Seal油封安装工具Discovery V8 only100LRT-51-010Replacer, Front & Rear Pinion Oil Seals差速器前后油封安装工具Discovery V8 and Freel

25、ander KV6101LRT-51-012Replacer, A*le Shaft Oil Seal前桥传动轴油封安装工具Freelander KV6 only102LRT-51-013A*le Locating Bracket后差速器定位支架Freelander KV6 only103LRT-51-014Shaft Remover半轴拆卸工具Freelander KV6 only104LRT-51-018/1Pinion Height Setting Block高度设定块Discovery V8 only105LRT-51-019Replacer, Pinion Oil Seal, Rea

26、r Differential.后差速器油封安装工具New Range Rover V8 only106LRT-51-020Replacer, Support Bearing, Rear Prop Shaft.后传动轴中央支撑轴承安装工具New Range Rover V8 only107LRT-51-021Replacer, Drive Shaft Oil Seal Rear.后轮半轴油封安装工具New Range Rover V8 only108LRT-51-022Remover/Replacer, Front Diff. Mounting Bush.前差速器固定胶套拆卸安装工具New Ra

27、nge Rover V8 only109LRT-51-023Remover/Replacer, Rear Diff. Mounting Bush.后差速器固定胶套拆卸安装工具New Range Rover V8 only110LRT-51-024Remover/Replacer, Sub-frame Mounting Bushes.副车架固定胶套拆卸安装工具New Range Rover V8 only111LRT-54-003Installer Oil Seal Front & Rear Hubs前后轮毂油封安装工具Discovery V8 only112LRT-54-008BRemover

28、 / Replacer Knuckle Ball Joint前桥上下球头拆卸工具Discovery V8 only113LRT-54-012Replacer, Driveshaft Seal传动轴油封安装工具Discovery V8 only114LRT-54-014Hub Disassembly / Assembly Tool轮毂分解组装工具Freelander KV6 only115LRT-54-015Anvil, Remover / Replacer, Front & Rear Hub Bearings前后轮毂轴承拆卸工具Freelander KV6 only116LRT-54-016S

29、upport, Front & Rear Hub Bearing Replacer前后轮毂轴承拆卸工具Freelander KV6 only117LRT-54-017Base, Hub Disassembly / Assembly前后轮毂轴承拆卸工具Freelander KV6 only118LRT-54-021Locator Rem / ReplBall Joint球头拆卸安装工具Discovery V8 only119LRT-54-022Locator Rem / ReplBall Joint球头拆卸安装工具Discovery V8 only120LRT-54-026Drive Shaft

30、 Remover.半轴拆卸工具Freelander KV6 and Range Rover V8121LRT-54-028Replacer, Driveshaft Oil Seal半轴油封安装工具New Range Rover V8 only122LRT-54-029Replacer, Pinion Oil Seal分动器输出轴油封安装工具New Range Rover V8 only123LRT-54-030Holding Tool, Pinion Tube.前差速器输入轴花键套固定工具New Range Rover V8 only124LRT-54-031Replacer, Housing

31、 Support Bearing.壳体支撑轴承安装工具New Range Rover V8 only125LRT-57-001Power Steering Test Adaptor助力转向测试接头Discovery V8 and Freelander KV6126LRT-57-002Adaptor Hose Hydraulic Pressure Test液压测试管路接头Discovery V8 and Freelander KV6127LRT-57-005Pressure Test Gauge & Hose压力测试表及管路Discovery V8 and Freelander KV6128LR

32、T-57-012Remover Drop Arm方向机下摆臂拆卸工具Discovery V8 only129LRT-57-017 Torque Setting Tool扭矩设定工具Freelander KV6 only130LRT-57-034AAdaptor, PAS Pressure Test助力转向压力测试接头Discovery V8 and Freelander KV6131LRT-57-035 Adaptor, PAS Pressure Test助力转向压力测试接头Discovery V8 and Freelander KV6132LRT-57-036 Steering Ball J

33、oint Seperator转向球头拆卸工具Discovery V8 and Range Rover V8133LRT-57-041 PAS Pressure Test Adaptor助力转向压力测试接头Discovery V8 only134LRT-57-043 Ball Joint Separator.转向球头拆卸工具Freelander KV6 only135LRT-57-044 PAS Disconnect Tool. 助力转向油管快速接头断开工具Freelander KV6 only136LRT-57-045 Setting Tool, Camber. 后倾角设定工具New Rang

34、e Rover V8 only137LRT-57-503 Replacer Input Shaft Seal输入轴油封安装工具Discovery V8 only138LRT-57-504 Replacer Output Shaft Seal输出轴油封安装工具Discovery V8 only139LRT-60-008 Remover / Replacer, Lower Arm Bush下拉臂胶套拆卸安装工具Freelander KV6 only140LRT-60-009 Rem / Repl Bush Rod End, Long ArmACE执行器端部胶套拆卸安装工具Discovery V8

35、only141LRT-60-010 Rem / ReplBush Short Arm连杆衬套拆装工具Discovery V8 and Freelander KV6142LRT-60-011 Pusher Rem / ReplRadius Arm Bush前直拉臂胶套拆卸工具Discovery V8 only143LRT-60-013 Rem / ReplBush (Panhard Rod)直拉臂胶套拆卸工具Discovery V8 and Freelander KV6144LRT-60-014A Accelerometer Remover加速度传感器拆卸工具Discovery V8 only1

36、45LRT-60-030 Remover/Replacer, Hub.轮毂拆装工具New Range Rover V8 only146LRT-60-031 Remover/Replacer, Lower Arm Bush.下拉杆胶套拆卸工具New Range Rover V8 only147LRT-60-032 Remover/Replacer, Tie Rod Bush.下球头拉杆New Range Rover V8 only148LRT-60-033 Remover/Replacer, Front & Rear Hub Bearings.前后轮毂轴承拆卸安装工具New Range Rove

37、r V8 only149LRT-60-033 Remover/Replacer, Front & Rear Hub Bearings.前后轮毂轴承拆卸安装工具New Range Rover V8 onlyNew Range Rover V8 onlyNew Range Rover V8 only150LRT-60-034Radius arm bush,remover(NSCLR0122)下直拉杆胶套拆卸安装工具Discovery V8 only151LRT-64-002 Remover / Replacer, Suspension Trailing Arm Bush直拉臂胶套拆卸工具Freel

38、ander KV6 only152LRT-64-003 Calibration Blocks后悬架高度校正块Discovery V8 only 153LRT-64-023 Remover, Trailing Arm Bush.拖车臂胶套拆卸工具Freelander KV6 only154LRT-64-024 Remover/Replacer, Upper Arm Bushes.上摆臂胶套拆卸工具New Range Rover V8 only155LRT-64-025 Remover/Replacer, Hub Bush Upper.上摆臂胶套拆卸工具New Range Rover V8 onl

39、y156LRT-64-026 Remover/Replacer, Hub Bush Lower.下摆臂胶套拆卸工具New Range Rover V8 only157LRT-64-027 Remover/Replacer, Bush Lower Arm Front.前下拉臂胶套安装拆卸工具New Range Rover V8 only158LRT-64-028 Remover/Replacer, Bush Lower Arm Rear.下摆臂胶套拆卸工具New Range Rover V8 only159LRT-70-007 Remover, Handbrake Cable,手刹线拆卸工具Fr

40、eelander KV6 only160LRT-70-500 Disc Brake Piston pressor碟刹活塞压缩工具Discovery V8 only161LRT-84-001Windcreen wiper arm setting tool前挡风玻璃雨刮臂设定工具Freelander KV6 New Range Rover162LRT-86-003-01 Adaptor/Flylead, Air-bag Deployment气囊引爆工具接头插脚Freelander KV6163LRT-86-003/08 Adaptor/Flylead, Air-bag Deployment气囊引爆

41、工具接头插脚Freelander KV6164LRT-86-003A Air-bag Deployment Tool气囊引爆工具Discovery V8 165LRT-86-006 Radio Removal Keys (Alpine)收音机拆卸工具Discovery V8 only and Freelander KV6166LRT-99-001 Torque Wrench, Preload预紧力扭矩扳手Discovery V8 only167LRT-99-002 Hand Press手动压缩工具Discovery V8 only168LRT-99-003 Replacer Bearing /

42、 Oil Seal Main Tool ( Handle )油封安装手柄Discovery V8 only169LRT-99-004 Impulse E*tractor ( UNF) Main Tool通用拉锤Freelander KV6 only 170LRT-99-006 Setting Gauge Bevel Pinion设定表Discovery V8 only171LRT-99-008A Support Bracket - V8 & Tdi ZF+ LT230 seriesZF变速器支撑架Discovery V8 only172LRT-99-010 Support Bracket - LT230 seriesLT230分动器支撑架Discovery V8 and Freelander KV6173LRT-99-019 Band-It Tool拗曲工具Discovery V8 and Freelander KV6174LRT-99-027 Pipe Cutter, E*haust.New Range Rover V8 only175