永磁电机潜水泵结构图 、技术性能参数表、外形图、尺寸表、自耦式安装简图、安装尺寸表.docx

附件A永磁电机潜水泵外形及结构图A.1永磁电机潜水泵的外形及结构见图A.1。1(b)内部结构图1吸水口；2一叶轮；3泵壳；4一下泵盖；5一下机封；6一上机封；7注油口；8润滑油室；9一下轴承；10一主轴；11永磁电机定子；12永磁电机转子；13永磁电机机壳；14一上轴承；15一上泵盖：16电缆接线腔；17一吊环；18电缆引入口；19一潜水电缆图A.1永磁电机潜水泵外形及结构图B.1永磁电机潜水泵的主要技术性能参数见表BJ0表BJ永磁电机潜水泵技术性能参数表序号潜水泵型号出水口通径mm流量m3h扬程m转速rpm电机功率kW永磁电机潜水泵效率%固体颗粒最大直径mm165YQ50-15-5.565501530005.559.130280YQ35-25-5.580352530005.558.0303100YQ95-12-5.5100951215005.567.835480YQ75-20-7.580752030007.566.3355100YQ45-40-11100454030007.567.7206I50YQ90-25-11150902515001168.6357I50YQ150-I2-111501501215001168.6458150YQ160-17-111501601715001170.5459200YQ220-10-112002201015001172.44510100YQ75-40-15100754030001570.13511200YQ270-12-152002701215001572.95012150YQ200-21-18.515020021150018.574.94513200YQ130-33-18.520013033150018.570.14514200YQ350-14-222003501415002269.25515150YQ250-24-301502502415003075.25016400YQ1000-8-304001000810003077.17517200YQ180-40-372001804015003772.74518250YQ470-18-372504701815003774.76019200YQ350-25-452003502515004575.85520250YQ570-20-452505702015004576.76521500YQ1200-9-455001200910004577.07522200YQ290-40-552002904015005571.05023200YQ380-31-552003803115005577.75524500YQ1500-10-5550015001010005577.68025250YQ700-23-752507002315007576.47026200YQ500-38-902005003815009076.66027300YQ900-25-903009002515009076.77028500YQ1800-12-9050018001210009079.08529250YQ850-30-lIO25085030150011077.17030300YQ1000-30-110300100030150011077.97531500YQ2200-14-132350220014100013279.09532350YQ1200-33-160350120033150016078.17533600YQ2800-16-160600280016100016078.89034350YQ1400-37-220350140037150022077.48035400YQ1700-42-280400170042150028077.985366OOYQ35OO-16.5-215600350016.5100021577.210537600YQ4000-20-315600400020100031576.3110注：实际运行过程中，永磁电机潜水泵的转速可V周。在电机额定功率范围内，根据运行工况实际需要，通过变频器调节电机转速，可实现不同的流量和扬程运行工况。(a)前视图(b)俯视图1吸水口；2一泵壳；3一下泵盖；4永磁电机机壳；5上泵盖；6电缆引入口;7吊环；8电缆护套；9通讯电缆护套图CJ永磁电机潜水泵外形图C.2永磁电机潜水泵的外形尺寸见表C.2。表C.2永磁电机潜水泵外形尺寸表序号潜水泵型号外形尺寸（mm）潜水泵净重kgLlL2WH165YQ50-15-5.5125170255950160280YQ35-25-5.51252002609501673100YQ95-12-5.5175270345990224480YQ75-20-7.51251902609601855100YQ45-40-1115024029510002306150YQ90-25-1123035046011302807150YQ150-12-11190300380IllO2848150YQI60-I7-1121032540511103409200YQ220-10-11210280400112060210100YQ75-40-15160240315105023811200YQ270-12-15220300430116021812150YQ200-21-18.5225355445113020013200YQ130-33-22260400520122028214200YQ350-14-22240330470120024615150YQ250-24-30245380457130031516400YQ1000-8-30500700920153075017200YQ180-40-37310450610132033018250YQ470-18-37265365520136534319200YQ350-25-45260405510135038020250YQ570-20-45280390555139037221500YQ1200-9-455007501000160080022200YQ290-40-55310450610143035523200YQ380-31-55280435550143040024500YQI500-10-555207501000170075025250YQ700-23-75310415595149057626200YQ500-38-90310485605149562027300YQ900-25-90325445635154063428500YQ1800-12-9055080011901765100O29250YQ850-30-10340460665160070030300YQ1000-30-HO3504756851625715315OOYQ22OO-14-13260085011901855120032350YQ1200-33-160365495720175082433600YQ2800-16-16065590012602100160034350YQ1400-37-2203905257601885114235400YQ1700-42-2804106008101990126736600YQ3500-16.5-21584080014151770180037600YQ4000-20-3157201030141523202200附录D永磁电机潜水泵自耦式安装示意图、安装尺寸表D.1永磁电机潜水泵自耦式安装示意见图DJo(b)右视图(a)前视图1耦合底座；2挂板；3出水管；4永磁电机潜水泵;5一吊链；6导轨；7导轨固定支架图D.1永磁电机潜水泵自耦式安装示意图D.2永磁电机潜水泵集水池自耦式安装示意见图D.2。注：1、在电机没有冷却水套时，最低运行水位应不低于H2；2、在电机有冷却水套时应淹没叶轮，最低运行水位应不低于H3；3、最高运行水位根据实际运行控制要求确定。(b)俯视图1一地脚螺栓；2耦合底座；3导轨；4导轨固定支架;5永磁电机潜水泵；6浮球开关；7一吊链图D.2永磁电机潜水泵集水池自耦式安装示意图D.3永磁电机潜水泵集水池自耦式安装尺寸见表D.3。表D.3永磁电机潜水泵集水池自耦式安装主要尺寸表序号潜水泵型号安装尺寸(mm)耦合底座预埋地脚螺栓规格导杆定位支架膨胀螺栓规格HlH2LXB165YQ50-15-5.530012001400X1000M12X5002-M8X70280YQ35-25-5.530012001400×1000M12X5002-M8X703100YQ95-12-5.53001000900×700M16×3002-M8×70480YQ75-20-7.530012001400X1000M12X5002-M8X705I00YQ45-40-1130012001400X1000M16×5002-M8X706150YQ90-25-1130012001400X1000M16×5002-M12X1057I50YQ150-12-113001000900×700M16×3002-M12×1058150YQ160-17-1130010001000×800M16×3002-M12×1059200YQ220-10-1I35011001400×1000M16×3002-M12×10510100YQ75-40-1530012001400X1000M16×5002-M8×7011200YQ270-12-1535012001400X1200M16×3002-M12X10512150YQ200-21-18.535011001000×800M16×3002-M12×10513200YQ130-33-2235012001600X1000M16X5002-M12X105142OOYQ35O-14-22350120015OO×13OOM16×3002-M12X10515150YQ250-24-3035012001100X900M16×3002-M12X10516400YQ1000-8-3050018001600×1400M36×8002-M12X10517200YQ180-40-3735012001600X1200M16×5002-M12X10518250YQ470-18-37350130015OO×13OOM24×5002-M12×10519200YQ350-25-4535013001100×900M16×3002-M12×10520250YQ570-20-4535013001600×1400M24×5002-M12×10521500YQ1200-9-4560017501700×1500M36×8002-M20×17022200YQ290-40-5535012001600X1200M16X5002-M12X10523200YQ380-31-5535013501200X1000M16×3002-M12X10524500YQ1500-10-5560017001700X1500M36×8002-M20×17025250YQ700-23-7535013001600×1400M24×5002-MI2×1O526200YQ500-38-9035013001200X1000M16×3002-M12X10527300YQ900-25-9035014001700X1400M24×5002-M12X10528500YQ1800-12-9060018001800X1600M36×8002-M20×17029250YQ850-30-11035014001700X1500M24×5002-M12×10530300YQ1000-30-11035015001700X1500M24×5002-M12×10531500YQ2200-14-13260019001900×1700M36×8002-M20×17032350YQ1200-33-160400160018OO×I5OOM24×5002-MI2×10533500YQ2800-16-16060020002000×I800M42×8002-M20×17034350YQ1400-37-22040017001800×1600M24×5002-M12×10535400YQ1700-42-28060022002200×I800M36×8002-M12×10536600YQ3500-16.5-21560020001900×1600M36×8002-M20×17037600YQ4000-20-31560024002800X1800M42×8002-M20×170注：1、表中主要尺寸含义：H1潜水泵吸入口距池底最小高度；H2潜水泵最小淹没深度；1.XB集水池安装孔最小尺寸。2、各种型号永磁电机潜水泵的耦合底座预埋地脚螺栓数量均为4个。3、各种型号永磁电机潜水泵出水法兰的公称压力等级均为PNLoMPa。